D80 GC Generator Set
360° Exterior View
360° Exterior View
360° Interior View
At a Glance
|
|
|
|
Overview
Caterpillar is leading the power generation marketplace with Power Solutions engineered to deliver unmatched flexibility, expandability, reliability, and cost-effectiveness.
Generator Set Specifications
+ -Maximum Rating | 80 ekW |
Minimum Rating | 80 ekW |
Emissions/Fuel Strategy | U.S. EPA Cert., Tier 3 |
Voltage | 208 to 600 Volts |
Frequency | 60 Hz |
Speed | 1800 rpm |
Duty Cycle | Standby |
Engine Specifications
+ -Engine Model | C4.4, In-line 4, 4-cycle diesel |
Bore | 4.1in |
Stroke | 5in |
Displacement | 269in³ |
Compression Ratio | 16.7:1 |
Aspiration | Turbocharged |
Fuel System | Common Rail |
Governor Type | Mechanical, ADEM™A4 |
Generator Set Dimensions
+ -Length - Maximum | 82.6in |
Width - Maximum | 43.3in |
Height - Maximum | 52.9in |
Dry Weight - Genset (maximum) | 950lb |
Standard Equipment:
Air Inlet System
+ --
Air cleaner; light duty with disposable element
-
Air cleaner
Cooling System
+ --
Radiator and cooling fan with guards
-
Fan drive, battery charging alternator drive
-
Caterpillar extended life coolant
-
Coolant drain line with valve
Control Panel
+ --
GCCP 1.2 Control panel
Exhaust System
+ --
Stub pipe, gaskets, raincap and SAE exhaust flange for customer use - shipped loose
Fuel System
+ --
Standard open set fuel tank/base supplied base, formed steel with single wall integral 24-hour fuel tank
Generator
+ --
Circuit breaker, IEC, 3 pole, mounted in tower panel
-
Voltage regulator (single phase sensing)
-
IP23 Protection
-
Segregated low voltage (AC/DC) wiring panel
-
12 Leads
-
Tower panel, IP22, bottom cable entry
Governing System
+ --
Mechanical and electrical governing system - model dependent
Lube System
+ --
Lubricating oil
-
Oil drain line with valve
Mounting System
+ --
Includes lifting provision and drag points
-
Termination points for coolant and lube oil drain lines
-
Captive linear vibration isolators between base and engine-generator
Starting/charging System
+ --
Batteries
-
24V battery with rack and cables
General
+ --
Engine and alternator pre-paint, Caterpillar yellow
Optional Equipment:
Alternator System
+ -3 Phase sensing
Anti-condensation heater
R Frame auxilliary winding
Permanent magnet excitation (PMG)
Circuit Breakers
+ -Circuit breaker upgrades - 4 Pole circuit reaker to 250A, 400A and 630 A
Cooling System
+ -Low coolant level shutdown
Coolant heater
Low coolant temperature alarm
Control Panel Options
+ -Earth fault (2 wire only)
Overload shutdown via breaker
Earth leakage (2 wire only)
Volt free contacts
Panel mounted audible alarm
Battery charger
GCCP 1.2 Control panel
Control panel heater
Voltage adjust potentiometer
Emergency stop with key
Speed adjust potentiometer
Enclosures
+ -Sound attenuated Level 2 enclosure
Fuel System
+ -High fuel level alarm
Open set narrow tankbase
Low fuel level alarm
Bunded fuel tank
Low fuel level shutdown
Compact skidbase for open set
Skidbase for CALG enclosure sets
Global Certifications
+ -Certification for CIS
Mounting Options
+ -Battery removal
Industrial silencer
Electronic governor
External single point lift - enclosure
Silencer installation kit
Special Packing/inspectons For Shipment
+ -PGS Test report @ 1.0 power factor
PGS Test report @ 0.8 power factor
General - Accessories / Miscellaneous
+ -Stone guards/rad trans flange
Packing case - canopied set
Packing case - compact set