3412C Generator Set
360° Exterior View
At a Glance
|
|
|
|
Overview
Caterpillar is leading the power generation marketplace with Power Solutions engineered to deliver unmatched flexibility, expandability, reliability, and cost-effectiveness.
Generator Set Specifications
+ -Maximum Rating | 800 ekW |
Minimum Rating | 635 ekW |
Emissions/Fuel Strategy | Low Fuel Consumption |
Voltage | 220 to 480 Volts |
Frequency | 60 Hz |
Speed | 1800 rpm |
Duty Cycle | Standby, Prime |
Engine Specifications
+ -Engine Model | 3412C TA, V-12, 4-Stroke Water-Cooled Diesel |
Bore | 5.4in |
Stroke | 6in |
Displacement | 1648.86in³ |
Compression Ratio | 13:00:01 |
Aspiration | TA |
Fuel System | Pump and Lines |
Governor Type | ADEM™ A5 |
Generator Set Dimensions
+ -Length - Maximum | 162.4in |
Width - Maximum | 78.3in |
Height - Maximum | 75in |
Dry Weight - Genset (minimum) | 5761lb |
Dry Weight - Genset (maximum) | 13275lb |
Standard Equipment:
Air Inlet System
+ --
Air cleaner, single element canister type
-
Single element canister type
Control Panel
+ --
High coolant temperature
-
Customer data link (Modbus RTU)
-
Low coolant temperature
-
Low coolant level
-
Communications:
-
Run/auto/ stop/control
-
Engine cycle crank
-
Generator temperature monitoring module
-
Power factor (per phase & average)
-
Remote CAN annunciator
-
Serial annunciator module data link
-
DC volts
-
Frequency (Hz)
-
Operating hours.
-
Emergency stop pushbutton
-
Digital I/O module
-
Local annunciator
-
Low oil pressure
-
Oil pressure (psi, kPa or bar)
-
Emergency stop
-
Warning shutdowns:
-
Volts (L-L & L-N)
-
Remote Serial annunciator
-
Speed adjust
-
Amps (per phase & average)
-
Voltage adjust
-
EMCP 4.2B
-
Overspeed
-
coolant temperature
-
Digital Indicator for:
-
RPM
-
Accessory module data link
-
Failure to start (overcrank)
-
Controls:
-
Compatible with the following optional modules:
Cooling System
+ --
Caterpillar extended life coolant
-
Radiator with guard (sized for 50 degrees C)
-
Fan and belt guards
-
Coolant drain line with valve
Exhaust System
+ --
Stainless steel exhaust flex with ANSI style outlet flange
Fuel System
+ --
Primary and Secondary fuel filters
-
Fuel priming pump
-
Water separator
Generator And Attachments
+ --
3 Phase sensing
-
SR4B self excited
-
Class F temperature rise
-
VR6B voltage regulator
-
Busbar termination
-
12 Leads
-
Class H insulation
-
2:1 Volts/Hz
-
Reactive droop
Governing System
+ --
Cat electronic governor
Lube System
+ --
Oil drain line with valve
-
Lubricating oil
-
Oil filter
Mounting System
+ --
Base, formed steel with linear vibration isolators between base and engine-generator
Starting / Charging System
+ --
Battery with rack, cables
-
45 Amp Charging alternator
-
Fuel shutoff solenoid
-
24 Volt starting motor
General
+ --
Paint - Caterpillar yellow except rails and radiators gloss black
Optional Equipment:
Air Inlet System
+ -Air cleaner - Dual element
Air cleaner - Heavy element
Air cleaner - single element
Certificates
+ -EU Certification
Circuit Breakers
+ -4 Pole Circuit breakerswith shunt trip
3 Pole Circuit breakers with shunt trip
Power terminal strip
Control Panel
+ -EMCP 4.3, EMCP 4.4
Temperature monitoring package
Vandal proof panel door
Generator running VFC
Earth leakage Ground fault relay
Common alarm/shutdown relay
Cooling System
+ -Jacket water heater
Radiator duct flange
Radiator removal
Exhaust System
+ -Muffler 10 dBA attenuation
Manifold and turbocharger guards
Muffler 35 dBA attenuation
Elbow mounting kit
Through wall installation kit
Fuel System
+ -Manual fuel transfer pump
Automatic fuel transfer system
Generator And Attachments
+ -Internal excitation (IE)
Anti-condensation heater
Permanent magnet excitation (PMG)
Oversize and premium generators
Governing System
+ -Electronic load share
Lube System
+ -Manual sump pump
Mounting System
+ -Fuel tank base (1200 Ltr)
Special Tests / Reports
+ -PGS Test report @ 1.0 power factor
PGS Test report @ 0.8 power factor
Factory witness test
Starting / Charging System
+ -Oversize battery set
Battery chargers
Heavy duty starting system
Battery disconnect switch
Battery removal
Enclosures
+ -DC lighting package
Weather protective enclosure (WP)
Sound attenuated enclosure (SA)