3516E Low Voltage Generator Set
At a Glance
|
Standby Rating
3000 ekW
|
|
Prime Power Rating
2725 ekW
|
|
Emissions/Fuel Strategy
Tier 2
|
|
Voltage
416 to 13,800 Volts
|
Request a Quote
Overview
Caterpillar is leading the power generation marketplace with Power Solutions engineered to deliver unmatched flexibility, expandability, reliability, and cost-effectiveness.
Generator Set Specifications
+
-
| Standby Rating |
3000 ekW |
| Prime Power Rating |
2725 ekW |
| Emissions/Fuel Strategy |
Tier 2 |
| Voltage |
416 to 13,800 Volts |
| Frequency |
60 Hz |
| Speed |
1800 rpm |
| Duty Cycle |
Standby, Mission Critical, Prime |
| Maximum Rating |
3000 ekW |
| Minimum Rating |
2725 ekW |
Engine Specifications
+
-
| Engine Model |
3516E, V-16, 4-Stroke, Water-Cooled Diesel |
| Bore |
6.69in |
| Stroke |
8.47in |
| Displacement |
4765in³ |
| Compression Ratio |
13.9:1 / 14.3:1 |
| Aspiration |
ATAAC |
| Fuel System |
MEUI |
| Governor Type |
Adem™ A5 |
Generator Set Dimensions
+
-
| Length - Maximum |
304in |
| Width - Maximum |
113in |
| Height - Maximum |
143in |
| Dry Weight - Genset (maximum) |
44930lb |
Standard Equipment:
Air Inlet System
+
-
-
Single element canister type with service indicator
-
Air cleaner
Fuel
+
-
-
Primary fuel filter with integral water separator
-
Fuel priming pump
Generator
+
-
-
IP23 Protection
-
Matched to the performance and output characteristics of Cat engines
Starting/charging
+
-
-
Heavy-duty starting system
-
Charging alternator
Control Panel
+
-
-
Over / under voltage (27/59)
-
Emergency stop pushbutton
-
Speed adjust
-
Accessory module data link
-
Generator phase sequence
-
Panel Lights
-
Alarm acknowledge
-
Generator mounted - rear facing
-
kW (per phase, average & percent)
-
Engine cool-down timer
-
Communications:
-
High coolant temperature
-
Warning / shutdown with common LED indication of shutdowns for:
-
Overcurrent (50/51)
-
Amps (per phase & average)
-
Oil pressure (psi, kPa or bar)
-
Serial annunciator module data link
-
24 Volt DC operation
-
EMCP 4.2B controller includes:
-
DC volts
-
Reverse reactive power (kVAr) (32RV)
-
6 Programmable digital inputs
-
2 Programmable relay outputs (Form C)
-
Frequency (Hz)
-
Customer data link (Modbus RTU)
-
Power Factor (per phase & average)
-
kW-hr (total)
-
EMCP 4.2B
-
Lamp test
-
kVA (per phase, average & percent)
-
kVAr-hr (total)
-
Coolant temperature
-
Text alarm / event descriptions
-
Over / under frequency (81 o/u)
-
kVAr (per phase, average & percent)
-
4 Programmable relay outputs (Form A)
-
Low coolant level
-
True RMS AC metering, 3-phase, +/-2% accuracy
-
Failure to start (overcrank)
-
Operating hours
-
Low coolant temperature
-
2 Programmable digital outputs
-
Low oil pressure
-
Controls:
-
Digital indication for:
-
Environmental sealed front face
-
Overspeed
-
Volts (L-L & L-N)
-
Reverse Power (kW) (32)
-
Engine cycle crank
-
Programmable protective relaying functions:
Cooling System
+
-
-
Fan and belt guards
-
JWAC
-
Radiator fan and fan drive
-
Coolant level sensors
-
Caterpillar extended life coolant
-
Coolant drain line with valve
Exhaust System
+
-
-
Flanged faced outlet(s)
-
Dry exhaust manifold
Fuel System
+
-
-
Fuel cooler; not included with packages without radiator
-
Fuel priming pump
-
Secondary fuel filters
-
Flexible fuel lines - shipped loose
Generators And Attachments
+
-
-
Class H insulation, Class F temperature rise at 40C ambient
(105C prime/130C standby)
-
NEMA standard hole pattern
-
Anti condensation space heater
-
Permanent magnet
-
Form wound
-
3 Phase brushless, salient pole
-
6 Lead
-
Winding temperature detectors
-
Right side extension terminal box, bus bar connections, top
mounted, bottom cable entry
Lube System
+
-
-
Gear type lube oil pump
-
Integral lube oil cooler
-
Fumes disposal
-
Oil drain lines and valve
-
Oil filter, filler and dipstick
-
Lubricating oil
Mounting System
+
-
-
Rubber anti-vibration mounts (shipped loose)
-
Rails - engine/generator/radiator mounting
Starting / Charging System
+
-
-
45 Amp charging alternator
-
Battery and battery rack w/cables
-
Battery disconnect switch
-
24 Volt electric starting motor
General
+
-
-
Right hand servicing
-
Paint: Caterpillar yellow with high gloss black rails & radiator
-
SAE standard rotation
-
Flywheel and flywheel housing-SAE No. 00
Optional Equipment:
Air Inlet System
+
-
Air inlet protection
Remote air inlet adapters
Heavy duty air cleaners
Dual element air cleaners
Circuit Breakers
+
-
2000, 2500, 3200, 4000 Amp, 4 Pole, IEC-Rated Circuit Breakers
Circuit breaker harnesses
Masterpact breaker connections
P Frame breaker connections
2000, 2500, 3200, 4000, 5000 Amp, 3 Pole, IEC Rated Circuit Breakers
Busbar connections
R Frame breaker connections
Cable entry options
1600, 2000, 2500, 3000, 4000, 5000 Amp, 3 Pole, UL-100% Rated Circuit Breakers
Optional busbar power connections
Power Termination
+
-
Circuit breakers, IEC compliant
Control Panel
+
-
Voltage raise / lower switch
PC monitoring (Remote and local)
Generator temperature monitoring
Remote speed adjust
Annunciator modules
EMCP 4.3, EMCP 4.4
Vandal proof panel door
Auxiliary box
Customer interface options
Ground
Language options
Load share module options
Mounting group - External box clips
Cooling System
+
-
Optional Serpentine radiators
Optional ATAAC radiators
Water level switch gauges
Expansion tanks
Exhaust System
+
-
Flexible fittings
Y Adapters
Elbows
Mufflers
Flanges
Flanges and exhaust fittings
Fuel System
+
-
Duplex fuel filters
Primary fuel filters
Generators And Attachments
+
-
Differential current transformers - 8.7 and 15 kV class
Alternator air cleaners
Instrumentation
+
-
Pyrometer and thermocouples
Lube System
+
-
Manual prelube pum
Electric prelube pump
Oil level regulator
Lube oil in standard sump
Mounting System
+
-
Spring type vibration isolators
IBC seismic vibration isolators NORAD
Puck style low efficiency lsolators
Power Connections
+
-
Neutral ground connections
2700 & 3000 Frame
Grounding groups
Special Tests / Reports
+
-
Fuel consumption test
Torsional vibration analysis
Standard engine test charge
IBC certifications
Generator set consumption test
Generator set test report
PGS test report @ 1.0 power factor
PGS test report @ 0.8 power factor
Starting / Charging System
+
-
Engine barring group
10, 20, 35 and 50 Amp battery chargers
Starter covers
Jacket water heaters
24 Volt battery set - Dry
Electric starting motors
Air starting motors
Air pressure regulator
General
+
-
US aid emblem
Special paint colors
